Toyota 4 Runner/Hilux/Surf

1987-1998 of release

Repair and car operation

Toyota 4Раннер
+ 1. Maintenance instruction
+ 2. Maintenance
+ 3. Engines
+ 4. Systems of heating, ventilation
+ 5. Fuel and exhaust systems
+ 6. Transmissions
+ 7. Transmission elements
+ 8. Brake system
+ 9. Suspension bracket and steering
+ 10. Body
- 11. Electric equipment
   11.1. Specifications
   11.2. Battery
   + 11.3. Ignition system
   11.4. Coil (and) ignitions
   11.5. Ignition distributor
   11.6. Check and installation of the moment of ignition
   11.7. Block of electronic ignition
   11.8. Induction sensor
   - 11.9. System of a charge of the battery
      11.9.1. Check of system of a charge of the battery
   + 11.10. Generator
   11.11. System of start-up of the engine
   + 11.12. Starter electric motor
   11.13. Traction relay
   11.14. Tension check
   11.15. Detection of short circuit
   11.16. Check of reliability of grounding
   11.17. Check of integrity of a chain
   11.18. Finding of not closed chain
   11.19. Search of malfunctions
   11.20. Safety locks
   11.21. Fusible crossing points
   11.22. Breakers
   11.23. Relay
   11.24. Breaker of indexes of turn / alarm system
   11.25. Switch of indexes of turn
   11.26. Lock of ignition and lock drum
   11.27. Switch of external lighting
   11.28. Screen wiper switch
   11.29. Lamps of headlights
   11.30. Adjustment of headlights
   11.31. Headlight case
   11.32. Replacement of lamps
   11.33. Receiver and loudspeakers
   11.34. Aerial
   + 11.35. Screen wiper electric motor
   11.36. Switch of heating of back glass
   11.37. Heater of back glass
   11.38. Guard of devices
   11.39. Sound signal
   11.40. Electric drive of mirrors
   11.41. Cruise control
   + 11.42. Window regulator electric drive
   11.43. Electric drive of door locks
   11.44. Safety cushions
+ 12. Electroschemes

11.9.1. Check of system of a charge of the battery

GENERAL INFORMATION

The scheme for check of a current of a charge of the battery

1. Generator
2. Voltmeter
3. Battery

4. Disconnect a wire
from a conclusion In
5. Ampermeter

PERFORMANCE ORDER

1. At malfunction of a chain of a charge of the battery before drawing a conclusion on failure of the generator execute the following checks.
2. Check a condition and a tension of a belt of the generator.
3. At detection of signs of wear a belt replace.
4. Check an inhaling of bolts of fastening of the generator and an adjusting bolt of a tension of a belt.
5. Check conducting of the generator and a tension regulator, reliability of fastening and a condition of sockets.
6. Check fusible crossing points, at detection of the fused crossing points of inserts find out the reason and eliminate.
7. Start the engine and check a sound published by the generator (the howling or squealing sound indicates wear of bearings).
8. Check electrolit density in the battery.
9. If density low, charge the battery (this point does not belong to unattended batteries).
10. Check completeness of a charge of the battery (at faulty section of the battery its recharge is possible).
11. Check tension on the battery on the idle engine. Tension should be about 12 Century.
12. Start the engine and again check tension which should be now from 13,5 to 15, 1 Century.
13. Include a driving beam of headlights. At normal work of system of a charge tension should fall and again increase.
14. If tension is higher than normal tension of a charge, replace a tension regulator.
15. If tension is lower normal, check a regulator and the generator, having arrived as follows.
	16. Remove from the generator a back cover, connect to weight F conclusion, start the engine, consider tension on the battery and compare to the standard.
17. If tension is higher standard, replace a tension regulator.
18. If tension is lower standard, check the generator (or in the absence of the ampermeter hand over in a car-care center workshop).
19. The generator is checked according to the scheme (see fig. The scheme for check of a current of a charge of the battery).
20. Finish engine turns to 2000 rpm, measure a current at the switched-off and included consumers (a driving beam of headlights and the fan of the heater which has been switched on on the maximum turns).
21. If the measured current less standard, repair or replace the generator.